Cissell 75LB PARTS Bedienungshandbuch

Shown with manual doubletimer control systemTechnical specificationsInstallation instructionsOperating instructionsMaintenanceIPSO - USA3101 South Hav

Page 1075 lb. Dryer Dimensions - Standard GassnoitacificepSerusaeM.S.UcirteMerusaeMyticapaC)neniLyrD(.sbl57gk43teksaBretemaiDsehcni73mm049htpeDsehcni6

Page 11DR75 Dryer Dimensions - Gas(Illustration)38.97“ (990 mm)75.19“ (1910 mm)33.07“ (840 mm)53.34“(1355 mm)14.79.1“(230 mm)9.25“(235 mm)7.87“(200

Page 12Electric connectionThe connection needs to be made in the wiring box at the back. Remove thecoverplate (G) in order to reach the connection cla

Page 13The gas supply pipe should be connected to the gas tap (I), which is on the right nextto the wiring box on the back.It is very important to hav

Page 14Gas Piping Installation1. The installation must conform with local codes, or inthe absence of local codes with the National FuelGas Code, ANSI

Page 15Gas Piping Installation (Illustrations)The dryer and it’s individual shutoff valve must be disconnected from the gas supplypiping system during

Page 16The size of the gas service pipe is dependant upon manyvariables, such as tees, lengths, etc. Specific pipe sizeshould be obtained from the gas

Page 17Gas Pipe Size ChartTOTAL BTU/HR(for LP Gas correcttotal BTU/HR below bymultiplying by .6)TOTALKCALHOURGAS PIPE SIZE FOR 1000 BTU (250 KCAL) NAT

Page 18Dryer Installation With Multiple ExhaustFor Exhaust Duct less than 14 feet (5 m) and 2elbows equivalent and less than 0.3 inches (8 mm)static p

Page 19Dryer Installation with Multiple ExhaustFor Exhaust Duct more than 14 feet (5 m) and 2 elbowsequivalent and more than 0.3 inches (8 mm) static

Page 2IMPORTANT NOTICES—PLEASE READFor optimum efficiency and safety, we recommend that you read the Manual before operating the equipment.Store this

Page 20 Suggested Minimum Dryer Make-up Air RequirementsDryer Dryer Pocket Maximum Air Flow Duct Size For Required Make-upModel Capacity

Page 21Dryer Installation With Separate Exhaust (Preferred)For ductwork less than 14 feet (5 m) and 2 elbows equivalentand less than 0.3 inches (8 mm)

Page 22Nothing is more important than air flow for the proper operation of aclothes dryer. A dryer is a pump which draws make-up air from theout-of-do

Page 23Rules for Safe Operation of Dryer1. Be sure your dryer is installed properly in accordance withthe recommended instructions.2. CAUTIONBe safe—s

Page 24NOTE: All HD dryers manufactured by are equipped with theDSI (Direct Spark Ignition) modules. These are designed to in-crease dryer efficiency

Page 25DIRECT SPARKIGNITION OPERATIONFLOW CHARTThe DSI module is powered by a 24 volt AC supplid by a stem-down trans-former in series with eight safe

Page 26General MaintenanceGENERALMAINTENANCE1. Clean lint trap daily. Remove lint before or aftereach day of operation. A clean lint trap will increas

Page 277. Periodically clean and examine exhaust system.8. Keep dryer area clean and free of gasoline,combustible materials and other flammable liquid

Page 28OPERATING INSTRUCTION - DOUBLE TIMER1. After loading the dryer with water washed clothes, close the loading door.2. Turn the 60 minute drying (

Page 29Ref. Part No. DescriptionNo.1 CSA-50045WH Jacket gas/electric (white)1 CSA-50052WH Jacket steam (white)2 TU7733 Screw self drilling 8-18 X 1/2

Page 3ATTENTION: L’ACHETEUR DOIT PLACER L’AVERTISSEMENT SUIVANT DANS UN ENDROIT CLAIR ET VISIBLE:ATTENTION: L’ACHETEUR

Page 30CSA-01510WH Complete control door assy.Note: Door rod assy. is not part of above complete assy.Ref. Part No. Description No.1 CSA-01511WH

Page 31Ref. Part No. DescriptionNo.1 SB-00915-0 Screw self drilling #10-16 X 5/82 CSA-01523WH Front panel, welded assy.-Coin2 CSA-01513WH Front panel,

Page 32Ref. Part No. DescriptionNo.1 EA-00607-0 Thermostat knob2 CA-13213-0 Thermostat bracket3 EA-00606-0 Thermostat4 CA-13215-0 Thermostat bracket a

Page 3324531212267WIRE BOX ASSEMBLYRef. Part No. DescriptionNo.CSA-01608WH Wire box door assy complete1 TUT316 Light LED 24V2 EA-11614-0 Timer-manual

Page 34Ref. Part No. DescriptionNo.MSD-00864WH Complete door assy (consists of items 1 thru 9 only)1 MD-00362-0 Door Glass - clear2 MD-00354-0 Gasket

Page 35Ref. Part No. DescriptionNo.CSA-01515WH Complete Asm - WMC75 OPLCSA-01594WH Complete Asm - WMC75 Coin1 CSA-01516WH Lint door w/latch holes(whit

Page 36Ref. Part No. DescriptionNo.CSA-01592-0 Basket & Spyder Asm.WMC75 - S.S.CSA-01639-0 Basket & Spyder Asm.WMC75 - Galv.1 CSA-01591-0 Stai

Page 37Ref. Part No. DescriptionNo.1 CA-13027-0 Top panel2 TU7733 Screw self drilling 8-18*1/2"3 CA-11936-0 Cover plate4 CA-13018-0 Backpanel5 TU

Page 38Ref. Part No. DescriptionNo.CSA-01334-0 Sail switch assy. complete1 CA-11854-0 Bracket sailswitch2 SB-00955-0 Screw phillips #4 X 3/4"3 TU

Page 39Ref. Part No. DescriptionNo.1 DA-11912-0 Pulley - basket2 Part of pulley3 DA-11914-0 Key4 C249 Hex nut 5/16-18"5 SB-00876-0 Stud - 5/16 -

Page 4WARNING: To avoid fire hazard, do not dry articles containing foam rubber or similar texturematerials. Do not put into this dryer flammable ite

Page 40Ref. Part No. DescriptionNo.1 DA-00477-0 Fan motor 3/4 HP 115/208/230/60/50/11 DA-00480-0 Fan motor 3/4 HP 230/460/60/3 & 220/380/50/32 T

Page 41Ref. Part No. DescriptionNo.1 DA--11904-0 Idler pulley 11”2 DA-00497-0 Basket belt - non-reversing - AX712 DA-00497-0 Basket belt -reversing -

Page 42Ref. Part No. DescriptionNo.ESA-00966-0 Wire box assy, rear, gas - 115V - 2 timerESA-00974-0 Wire box assy, rear, gas - 208/240V - 2 timer1 CA-

Page 43Ref. Part No. DescriptionNo.GSA-0780-0 Comp. assy. - Nat. gas1 GSA-00767-0 Housing gas burner2 TU11613-0 Lock washer 10 external tooth3 SB-0083

Page 5IPSO DRYER WARRANTYIPSO warrants all new equipment (and the original parts thereof) to be free from defects in material or workmanship fora p

Page 6ContentsSafety Instructions ...2-4Cissell Dryer Warranty ...

Page 7Rotation in two directionsRotation dans les deux sensDrehbewigung in zweiRichtungenMovimiento rotativo en losdos sentidosCautionAttentionAchtung

Page 8Unpacking/General Installation (All Dryers)Upon arrival of the equipment, any damage in shipmentshould be reported to the carrier immediately.Up

Page 9Unpacking/General Installation (All Dryers)The dryer is so designed that when an operator opens thedryer door, the basket and exhaust fan stop.